in-line 6 overheating problem

[Destroyer]

Originally Posted by moneyhole

I posted some pics of my boat-only had 1 of the motor. How expensive is it to have the lower unit water pump replaced if that is my problem? I have the in-line 6 with the heat exchanger and I'm not sure of which outdrive I have as it was painted over-completely with black paint. I had the muffs on -fired the boat and after 5 mins she climbed to 160, 180 200 then I shut it down @220 degrees or so. I let it cool off and placed a tub of water covering the intake lower unit holes and it bubbled some but temp still climbed. I didn't let it get anywhere near as hot and called it a day. I really want to fix her- it's been re-wired bow to stern, engine swapped in 'o8 with a known good running engine, but I did go thru the parts today and realized they used the old engine t'stat. That was cheesy. After it cooled down, I opened the drain ports & it had no water what so ever in the heat exchanger & I'm sure the manifold as well. What are ya'lls thoughts? Greatly appreicate them.

Price depends on if you do the labor yourself and what the condition is of the inside of your outdrive. I don't know exactly what the cost is for your unit, but from experience I can tell you that most impellers run around $20 and full impeller kits run about $50. Do a search on iboats.com. for your model.

On your heat exchanger comment, are you saying that the raw water side had no water in it, or are you saying that the fresh water side was empty? If it's the fresh water side did you fill it before you tested it? That part of your cooling system is a sealed system and should not have gone dry. If you didn't fill it, fill it and test again. If it's the raw water side, I'd suspect a blockage somewhere. My thinking being that even if your impeller was gone, the force of the water pressure coming through the muffs would have been enough to at least wet everything. Only a blockage would prevent the water from reaching the heat exchanger. Understand that this is pure speculation since I don't know what type of system you have, and you haven't posted any pics. At the very least you should change your impeller. (It's just good practice to change the impeller and the lower unit oil at the start of every boating season.)