rebuild vs New motor

[wildtalk]

oil is injection .. I did baby it last year due to being a newbie,, Will run in a bit harder this year,,, Thanks for all the info,, always great to get sound advice,, thanks all

[wildtalk]

I will have to invest in a compression tester,,, what should each cylinder be at warm temp ?

[wildtalk]

I will need invest in a compression tester,,, what should each cylinder test at warm temp ?

[reelapeelin]

A 4-stroke Suzuki 140 would work good on that CC...it won't have the giddy-up the present motor has, but will be smooth, economical and reliable...several of the guys here have them and like 'em...

[THEFERMANATOR]

If you're still running teh VRO oil injection and getting alot of smoke, then you either have a bad VRO pump or an air leak in teh fuel line before the fuel pump. An air leak before the fuel pump will cause it to pump air with the fuel, and the fuel pump pumps in a metered amount of fuel for each stroke of teh fuel pump. If it is pumping air instead of fuel, then it will be pumping extra oil since there is no fuel to mix with it. Also when the fuel pump pumps air it will go from 100:1 which is the idle setting to the 50:1 which is the mid and upper setting. The fuel pump makes the change over based on how fast it pumps, and when it is pumping air it will go faster and pump EXTRA oil. Get the bugs worked out and chances are you'll have a good engine.

[brisboats]

Ya what Ferm said. Compression test that motor and if it checks out work with it. The smoking can be toned down with the right oil. Those motors are now being sought after round here, the word is out. They were reliable and well built, only weak link is the optical ignition and that isn't all that bad. Tell your passengers the smoke is to keep the bugs away and run it like you stole it.

Brian

[reelapeelin]

Originally Posted by THEFERMANATOR

If you're still running teh VRO oil injection and getting alot of smoke, then you either have a bad VRO pump or an air leak in teh fuel line before the fuel pump. An air leak before the fuel pump will cause it to pump air with the fuel, and the fuel pump pumps in a metered amount of fuel for each stroke of teh fuel pump. If it is pumping air instead of fuel, then it will be pumping extra oil since there is no fuel to mix with it. Also when the fuel pump pumps air it will go from 100:1 which is the idle setting to the 50:1 which is the mid and upper setting. The fuel pump makes the change over based on how fast it pumps, and when it is pumping air it will go faster and pump EXTRA oil. Get the bugs worked out and chances are you'll have a good engine.

Man I was hopin' SOMEBODY would jump in here w/a solution...check out what FERM is talkin' about!!...one little prob like that can be all the difference...good call, Ferm!!...