|
|
#1
|
||||
|
||||
alil blockage?
i just wrote this post on another forum..so i'll just copy and paste it to save time lol
"well a week or so ago..i installed a new waterpump because i was getting a overheat alarm when i hit 40mph, i dropped boat in water to check it out...got out about 50ft from dock.. hit a sand bar then broke my steering cable trying to get off it...made it back to dock..no symptoms of overheating or blockage... yesterday i installed a new steering cable and decided i'll go fishing and test out the water pump again ..dropped boat in water last night....warmed her up for about 5 mins.. took off..got outside of the no wake zone and hit the throttle...jump up on plane and immediately get a overheat alarm....$#@%!....i knew this was not good...i turned her around and coasted back into dock slowly.. praying i wouldnt blow this motor also.....docked..turned off engine pulled cowling...she was hot!..no false alarm this time. tonight..i decided to pull the heads to check/clean the water circulation system....wow..there she was...both sides full of sand! blocked up like you just ate a whole block of govt. cheese! before i pulled the heads i checked compression..all good...luckily i seen no signs of damaged cyl's. rings or pistons. tommorow gonna flush her out and check more passageways...here's some pics of what less than 2ft of water and a sand bar will do to your motor. starboard side   port side   '
__________________
Kajun\'s V18 Gallery 
|
|
#2
12-18-2006, 01:57 AM
|
||||
|
||||
|
Re: alil blockage?
You have got to feel better knowing what the cause is? Good luck. Get her back together and there is still time to catch a few Rock ;D
Airslot
__________________
Airslot Airslot's V-20 Gallery
|
|
#5
12-18-2006, 05:09 PM
|
||||
|
||||
|
Re: alil blockage?
WOW! Glad you found it!
__________________
 1994 Wellcraft V21
|
|
#6
12-18-2006, 05:46 PM
|
||||
|
||||
|
Re: alil blockage?
Hopefully you can get it all cleaned out and back in shape without any problems. Good luck Kajun.
__________________
Heavily medicated for your protection.
|
|
#7
12-18-2006, 09:10 PM
|
||||
|
||||
|
Re: alil blockage?
yea i'm sure glad i found it too ;D...i think i was very lucky i didnt blow another motor......i should have it back together and in the water to test by end of the week....i couldnt do anything today i rake and bagged leaves in the front yard...19 friggn bags!!...tommorow is back yard.. :o
__________________
Kajun\'s V18 Gallery
|
|
#8
12-19-2006, 04:44 PM
|
||||
|
||||
|
Re: alil blockage?
Blow em into the neighbors yard. ;D
I don't have neighbors next to me so I just blow em into the woods.
__________________
1994 Wellcraft V21
|
|
#10
12-21-2006, 01:49 AM
|
|||
|
|||
|
Re: alil blockage?
That's a LOT of sand!!! Be careful not to get any of that sand inside the cylinder.
__________________
1971 222 Hiliner 1973 23 Seacraft Center Console 1973 23 Seacraft Sceptre 1971 25 Seacraft Seafari 1972 28 Cary
|
 |
|
|
Linear Mode
