|
|
#1
|
|||
|
|||
150 Suzuki 4 stroke won't start
This is a 2006 engine with 185 hrs, and it has been well maintained. The tank got water in it and the engine quit. The water issue is being resolved but I bought a 6 gallon tank and new hose to be able to ride now.
The fuel is new as is the tank but it won't start . I am not a mechanic, but i am inclined. Can anyone give me advice where to start. I did remove the injectors and drained the fuel rail and let it dry out. Still won't start. Any ideas? Pjay 
Last edited by pjayswell; 08-08-2015 at 11:02 AM. Reason: change engine size 
|
|
#2
08-08-2015, 11:17 AM
|
||||
|
||||
Air in the lines...
|
|
#3
08-08-2015, 11:22 AM
|
||||
|
||||
|
Are you sure you have fresh fuel to the rails? Did you drain the vapor tank at the engine and fuel filter at the engine?
__________________
2011 SUNDANCE B20CCR SKIFF, 2011 YAMAHA 90HP 4 STROKE, 2011 KARAVAN SINGLE AXLE ALUMINUM TRAILER, LOWRANCE ELITE-7 HDI, MINN KOTA RIPTIDE TROLLING MOTOR 2000CC HYDRA-SPORT 225+HP EVINRUDE SOLD  AND THE PINK JEEP!!!! R.I.P. http://www.wellcraftv20.com/communit...ad.php?t=11664 
|
|
#4
08-08-2015, 07:22 PM
|
||||
|
||||
|
is it one of those new unvented tanks? Open the lid..
Did you have a water separator/10 micron filter connected when you had the problem with water? It was running good ?and then you got water and it died? There was water in the rail? There is a low pressure fuel filter & pump (easy) and a high pressure fuel pump & filter (hard). Check the low pressure filter for water. If it aint in there it aint anywhere. You may have an airlock now. Check that it pumps fuel to the low pressure filter. Don't take hard things apart before you try the easy ones. They are first in line I have a pdf of theSuzuki DF140 service manual. It might be similar enough to help you. Send me a PM and I'll email you a link to download it from Google Drive.
__________________
1984 V20 "Express" & 2003 Suzuki DF140 (SOLD!) 2000 GradyWhite 265 Express YouTube/SkunkBoat https://www.youtube.com/channel/UC4F...znGospVOD6EJuw Transom Rebuild https://www.youtube.com/watch?v=EEz94NbKCh0 https://www.youtube.com/watch?v=Oe_ZmPOUCNc Last edited by SkunkBoat; 08-08-2015 at 07:28 PM.
|
|
#5
08-24-2015, 08:35 AM
|
|||
|
|||
|
Running again
Quote:
The motor then started rite up. Tomorrow I'll head back to the lake to test it again. Thanks to all for the advice Pjayswell
|
|
#6
08-25-2015, 09:32 AM
|
|||
|
|||
|
My 140 has a small fuel reservoir on the right side of the motor, if you have one of those, it would be full of bad fuel and need to be drained.
My 140 will run at idle for at least 10 minutes without running out of fuel when the main line to the tank is disconnected.
__________________
*************************************** Stay Safe!  Sold - 1984 V-20 Cuddy with a 2003 Johnson 140 hp gas sippin 4-stroke. 1995 Ranger 250C with a 2015 Suzuki 300 hp 4-stroke.
|
 |
|
|
Linear Mode
